KTM 990 Super Duke / R 2009: programma di manutenzione
Il programma di manutenzione qui sotto per la KTM 990 Super Duke / R del 2009 copre gli intervalli di manutenzione consigliati dal produttore per olio, manutenzione generale, candele, gioco valvole, liquido di raffreddamento, filtro dell'aria, liquido dei freni, pneumatici, manutenzione della catena di trasmissione e batteria. Gli intervalli sono mostrati in chilometri di default e possono essere cambiati in miglia.
999ccCilindrata
51Voci di manutenzione
Manuale ufficiale del produttore
Fonte: KTM Official Manuals (questo documento copre gli anni modello 2008–2013): azwecdnepstoragewebsiteuploads.azureedge.net
Programma completo
| Intervento | Intervallo | Difficoltà | Note |
|---|---|---|---|
| Change engine oil and oil filter | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Moderato | Change engine oil and oil filter. |
| Clean oil screens of engine and oil tank | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Moderato | Clean the oil screens of the engine and oil tank. |
| Clean magnetic drain plugs of engine and oil tank | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Clean the magnetic drain plugs of the engine and oil tank. |
| Check oil lines for damage and kink-less arrangement | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Inspect oil lines for damage and correct routing. |
| Renew spark plugs | Ogni 15,000 km · Ogni 24 mesi | Moderato | Replace spark plugs. |
| Check and adjust valve clearance | Ogni 15,000 km (la prima volta a 1,000 km) · Ogni 24 mesi | Avanzato | Check and adjust valve clearances (shim-under-bucket LC8 V-twin). Note: on the combined 990 Super Duke/R document's chart, the 1000km initial valve-clearance checkpoint is explicitly annotated '(Super Duke only)' - i.e. the higher-output R variant is NOT dotted for this specific initial-service check (both trims share the recurring 15000km/2yr checkpoint). |
| Check engine fastening bolts for tight fit | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check engine fastening bolts for tightness. |
| Check all engine bolts accessible from the outside for tight fit | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check externally-accessible engine bolts for tightness. |
| Check clutch linings | Ogni 15,000 km · Ogni 24 mesi | Moderato | Inspect clutch friction plate linings for wear. |
| Check clutch pressure booster system | Ogni 15,000 km · Ogni 24 mesi | Moderato | Check the clutch pressure booster system. |
| Check rubber boot for cracks or leaks | Ogni 15,000 km (la prima volta a 1,000 km) · Ogni 24 mesi | Facile | Inspect the throttle body/carburetor rubber boot for cracks or leaks. |
| Check fault memory with the KTM diagnosis tool | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Read the ECU fault memory with the KTM diagnosis tool. |
| Perform a status check of neutral, clutch, 2nd/3rd gear and side stand switch using the KTM diagnosis tool | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Perform a status check of neutral/clutch/gear/side-stand switches via the diagnosis tool. |
| Check the fuel hose, hoses on the vacuum sensors and secondary air system hoses for correct installation and damage | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Inspect fuel hose, vacuum sensor hoses, and secondary air system hoses. |
| Replace the O-ring on the fuel hose connection and check for leaks | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Replace the fuel hose connection O-ring and check for leaks. |
| Check the wiring harness on the throttle body for proper installation and damage | Ogni 15,000 km (la prima volta a 1,000 km) · Ogni 24 mesi | Facile | Inspect the throttle body wiring harness. |
| Check the vent hoses and fuel lines for damage and kink-free installation | Ogni 15,000 km (la prima volta a 1,000 km) · Ogni 24 mesi | Facile | Inspect vent hoses and fuel lines for damage/kinking. |
| Check cooling system for leaks and antifreeze protection | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check cooling system for leaks and antifreeze protection level. |
| Check radiator fan for proper operation | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Verify radiator fan operation. |
| Check the exhaust system for leaks and correct suspension and the clamps for a tight fit | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Inspect exhaust system for leaks, correct mounting, and clamp tightness. |
| Replace the graphite gasket in the rear exhaust manifold slide | Ogni 15,000 km · Ogni 24 mesi | Moderato | Replace the graphite gasket in the rear exhaust manifold slide. |
| Check actuating cables for damage, smooth operation, and kink-less arrangement, adjust and lubricate | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check, adjust and lubricate actuating cables. |
| Check the oil level in the hydraulic clutch reservoir | Ogni 7,500 km · Ogni 12 mesi | Facile | Check hydraulic clutch reservoir oil level. |
| Check air filter, renew if necessary, clean air filter box | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check air filter and renew if necessary; clean the air filter box. |
| Check cables for damage and kink-less arrangement | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Inspect general cables for damage/kinking. |
| Check headlamp adjustment | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check and adjust headlamp aim. |
| Check electrical system for function (low/high beams, stop light, turn indicators, headlamp, flasher, tell-tale lamps, speedometer illumination, horn, side-stand switch, clutch switch, emergency-off switch) | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Verify function of lighting, indicators, horn, and safety switches. |
| Make sure all bolts and nuts are tight | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | General fastener tightness check. |
| Check brake fluid level, lining thickness, and brake discs | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check brake fluid level, pad lining thickness, and brake discs. |
| Change brake fluid | Ogni 15,000 km · Ogni 24 mesi | Moderato | Flush and replace brake fluid. Motorex DOT 5.1 recommended. |
| Check brake lines for damage and leaks | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Inspect brake lines for damage/leaks. |
| Check/adjust smooth operation, free travel of handbrake/footbrake levers | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check and adjust hand/foot brake lever free travel. |
| Check bolts of brake system for tight fit | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check brake system bolts for tightness. |
| Check suspension strut and fork for leaks and proper operation | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Moderato | Inspect shock absorber and fork for leaks and proper operation. |
| Clean fork dust sleeves | Ogni 7,500 km · Ogni 12 mesi | Facile | Clean fork leg dust seal sleeves. |
| Bleed fork legs | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Moderato | Bleed air from the fork legs. |
| Check swinging-fork pivot | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Moderato | Check swingarm pivot. |
| Check/adjust steering-head bearing | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Moderato | Check and adjust steering head bearing play. |
| Check all chassis bolts for tight fit (fork plates, fork leg, axle nuts/bolts, swinging-fork pivot, reversing lever, suspension strut) | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | General chassis fastener tightness check. |
| Check rim joint | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check wheel rim joint. |
| Check tire condition and inflation pressure | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check tire tread condition and inflation pressure. |
| Check chain, sprockets and chain guides for wear, force fit and tension | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Inspect chain, sprockets and chain guides for wear and tension. |
| Check bolts on pinion and chain sprocket for locking devices and a tight fit | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Check pinion/chain sprocket bolts and locking devices. |
| Lubricate chain | Ogni 7,500 km (la prima volta a 1,000 km) · Ogni 12 mesi | Facile | Lubricate the drive chain. |
| Check wheel bearings and jerk damper for play | Ogni 7,500 km · Ogni 12 mesi | Moderato | Check wheel bearings and cush-drive jerk damper for play. |
| Perform complete fork maintenance | Ogni 15,000 km · Ogni 24 mesi | Avanzato | Full fork service/rebuild. |
| Perform complete suspension strut (shock absorber) maintenance | Ogni 15,000 km · Ogni 24 mesi | Avanzato | Full shock absorber service/rebuild. |
| Clean and lubricate steering-head bearing and sealing elements | Ogni 12 mesi | Moderato | Clean and re-grease steering head bearing and seals. |
| Treat the electrical contacts and switches with contact spray | Ogni 12 mesi | Facile | Apply contact spray to electrical contacts and switches. |
| Treat battery connections with contact grease | Ogni 12 mesi | Facile | Apply contact grease to battery terminal connections. |
| Change coolant fluid | Ogni 15,000 km · Ogni 24 mesi | Moderato | Drain and replace engine coolant. |
Nessuna voce di manutenzione corrisponde alla tua ricerca.
Facile: attrezzi di base, semplice Facile–Moderato: varia a seconda dell'intervento — a metà tra i due Moderato: un po' di manualità meccanica aiuta Avanzato: attrezzi/competenze specifiche, ma fattibile da soli Esperto: richiede esperienza significativa Professionale: consigliata officina o concessionario
Cosa scade?
Inserisci il tuo chilometraggio attuale (km) per vedere cosa sta per scadere.
Moto correlate
Hai notato qualcosa che non va?
Dicci cosa va corretto nel programma qui sopra per la KTM 990 Super Duke / R del 2009.