KTM 250 EXC 2015 – underhållsschema
Underhållsschemat nedan för KTM 250 EXC 2015 täcker tillverkarens rekommenderade serviceintervall för allmänt underhåll, batteri, däck, underhåll av drivkedja, bromsvätska, tändstift, olja, kylvätska och luftfilter. Intervallen visas i kilometer som standard och kan växlas till miles.
249ccMotorvolym
52Underhållspunkter
Officiell tillverkarmanual
Källa: KTM 2015 125/200/250/300 EXC Owner's Manual (official content, mirrored via en.enduro.team): en.enduro.team
Fullständigt schema
| Uppgift | Intervall | Svårighetsgrad | Anteckningar |
|---|---|---|---|
| Check that the electrical equipment is functioning properly | Var 20 drifttimmer | Enkel | Check electrical equipment operation. |
| Check and charge the battery | Var 20 drifttimmer | Enkel | Check battery state of charge and charge if necessary. |
| Check the front brake linings | Var 20 drifttimmer | Enkel | Check front brake pad wear. |
| Check the rear brake linings | Var 20 drifttimmer | Enkel | Check rear brake pad wear. |
| Check the brake discs | Var 20 drifttimmer | Enkel | Check front and rear brake disc condition. |
| Check the swingarm bearing | Var 40 drifttimmer | Medel | Check swingarm bearing play. |
| Check the heim joints at the top and bottom of the shock absorber | Var 20 drifttimmer | Medel | Check shock absorber heim (spherical) joint play, top and bottom. |
| Check the tire condition | Var 20 drifttimmer | Enkel | Check tire tread and casing condition. |
| Check the tire air pressure | Var 20 drifttimmer | Enkel | Check and correct tire pressure. |
| Check the wheel bearing for play | Var 20 drifttimmer | Medel | Check front/rear wheel bearing play. |
| Check the rim run-out | Var 20 drifttimmer | Medel | Check wheel rim trueness. |
| Check the spoke tension | Var 20 drifttimmer | Enkel | Check and correct spoke tension. |
| Check the chain, rear sprocket, engine sprocket, and chain guide | Var 20 drifttimmer | Enkel | Inspect drive chain, rear sprocket, engine sprocket, and chain guide for wear. |
| Check the chain tension | Var 20 drifttimmer | Enkel | Check and adjust chain tension. |
| Grease all moving parts | Var 20 drifttimmer | Enkel | Grease side stand, hand lever pivots, chain, and other moving parts; check for smooth operation. |
| Check/correct the fluid level of the hydraulic clutch | Var 20 drifttimmer | Enkel | Check and correct hydraulic clutch fluid reservoir level. |
| Check the front brake fluid level | Var 20 drifttimmer | Enkel | Check front brake fluid reservoir level. |
| Check the free travel of the hand brake lever | Var 20 drifttimmer | Enkel | Check and adjust front brake lever free play. |
| Check the play of the steering head bearing | Var 20 drifttimmer | Medel | Check steering head bearing for play. |
| Change the spark plug and spark plug connector | Var 20 drifttimmer | Enkel | Replace spark plug and spark plug connector. |
| Check the intake diaphragm | Var 20 drifttimmer | Medel | Check reed-valve intake diaphragm condition. |
| Check the exhaust control for functioning and smooth operation | Var 40 drifttimmer | Medel | Check 2-stroke power-valve exhaust control system operation. |
| Check the clutch | Var 40 drifttimmer | Medel | Check clutch operation and wear. |
| Change the gear oil | Var 20 drifttimmer | Medel | Change transmission gear oil. |
| Check all hoses and sleeves for cracking, leaks, and incorrect routing | Var 20 drifttimmer | Enkel | Inspect fuel, cooling, bleeder, and drainage hoses/sleeves. |
| Grease the steering head bearing | Var 12 månader | Medel | Disassemble and re-grease steering head bearing. |
| Check/set the carburetor components | Var 12 månader · Var 40 drifttimmer · Byt var 12 månader | Medel | Check and adjust carburetor components. |
| Perform a fork service | Var 40 drifttimmer | Avancerad | Full fork service (oil change, seal inspection). |
| Service the shock absorber | Var 40 drifttimmer | Avancerad | Full shock absorber service (nitrogen charge, oil, seals). |
| Check the starter drive | Var 40 drifttimmer | Medel | Check electric starter drive mechanism. |
| Change the piston and check the cylinder | Var 80 drifttimmer | Avancerad | Replace piston/rings, inspect cylinder bore. |
| Change the connecting rod, conrod bearing, and crank pin | Var 80 drifttimmer | Expert | Replace connecting rod, big-end bearing, and crank pin -- bottom-end rebuild. |
| Check the transmission and shift mechanism | Var 80 drifttimmer | Expert | Inspect gearbox and shift mechanism. |
| Change all engine bearings | Var 80 drifttimmer | Expert | Replace all engine crankcase/gearbox bearings. |
| Check the antifreeze and coolant level | Var 20 drifttimmer | Enkel | Check coolant level and antifreeze concentration. |
| Check the cables for damage and routing without sharp bends | Var 20 drifttimmer | Enkel | Inspect control cables for damage/kinks. |
| Check that the throttle cables are undamaged, routed without sharp bends, and set correctly | Var 20 drifttimmer | Enkel | Inspect throttle cable routing and adjustment. |
| Clean the air filter and air filter box | Var 20 drifttimmer | Enkel | Clean air filter element and air filter box. |
| Change the glass fiber yarn filling of the main silencer | Var 20 drifttimmer | Medel | Repack main silencer glass-fiber baffling. |
| Check the screws and nuts for tightness | Var 20 drifttimmer | Enkel | Check tightness of accessible fasteners. |
| Check the headlight setting | Var 20 drifttimmer | Enkel | Check and adjust headlight aim. |
| Check the idle | Var 20 drifttimmer | Enkel | Check idle speed. |
| Final check: check the vehicle for safe operation and take a test ride | Var 20 drifttimmer | Enkel | Road test and final safety check. |
| Make the service entry in the KTM Dealer.net and in the Service and Warranty Booklet | Var 20 drifttimmer | Enkel | Record service in dealer system and booklet. |
| Change the hydraulic clutch fluid | Var 12 månader | Medel | Drain and replace hydraulic clutch fluid. |
| Change the front brake fluid | Var 12 månader | Medel | Drain and replace front brake fluid. |
| Change the rear brake fluid | Var 12 månader | Medel | Drain and replace rear brake fluid. |
| Check the brake lines for damage and leakage | Var 20 drifttimmer | Enkel | Inspect brake lines/hoses for damage and leaks. |
| Check the rear brake fluid level | Var 20 drifttimmer | Enkel | Check rear brake fluid reservoir level. |
| Check the free travel of the foot brake lever | Var 20 drifttimmer | Enkel | Check and adjust rear brake pedal free play. |
| Check the frame and swingarm | Var 20 drifttimmer | Medel | Inspect frame and swingarm for cracks/damage. |
| Check the wheel hubs | Var 20 drifttimmer | Enkel | Check wheel hub condition. |
Inga underhållspunkter matchar din sökning.
Enkel: grundläggande verktyg, okomplicerat Enkel–Medel: varierar beroende på uppgift — någonstans mellan de två Medel: viss mekanisk kunskap hjälper Avancerad: specialverktyg/kunskap krävs, men fortfarande görbart själv Expert: betydande erfarenhet krävs Yrkesnivå: verkstad eller återförsäljare rekommenderas
Vad är dags?
Ange ditt aktuella miltal (km) för att se vad som är på väg.
Liknande motorcyklar
Har du upptäckt något fel?
Berätta vad som behöver rättas till i schemat ovan för KTM 250 EXC 2015.